UH-60 Blackhawk – Corporal Frisk

That Sweden has had a rough time with their NH 90-fleet is no secret. The HKP 14 as it is known locally was delayed to the extent that a batch of 15 UH-60M Blackhawk had to be acquired as a stop-gap for the MEDEVAC-role in Afghanistan due to the Swedish Super Pumas being retired and the NH90 still being quite some way off from entering service. The UH-60M has been a stunning success for the Swedes, becoming a reliable workhorse for the Swedish Armed Forces in general and the airmobile soldiers of the K 3 Livregementets hussarer (Life Regiment Hussars) in particular.

A US Navy MH-60R Seahawk from HSM-78 “Blue Hawks” releases flares during a training exercise. Note the half-full sonobouy dispenser (and lack of port side door), large radar disk under the front fuselage, and aft landing gear being significantly forward compared to a UH-60. Source: U.S. Navy photo by Mass Communication Specialist 2nd Class Sean M. Castellano via Wikimedia Commons

Now, unlike the situation in Finland where the NH90 eventually overcame the teething troubles to be widely accepted as a fully functioning and integrated part of the Finnish Defence Forces, the NH90 in Sweden has continued to struggle. To the extent that questions about the future of the platform has continued to be raised at regular intervals. A key part of the question is the role of the maritime mission sets which currently is outside the scope of Blackhawk operations. Instead, the Swedish NH 90-fleet sport two different versions: the transport-roled HKP 14E and the maritime-roled HKP 14F. Crucially, the HKP 14F is not an NH90 FFH, but a uniquely Swedish version based on the NH90 TTH (in addition both versions sport a higher cabin to provide a more ergonomic working environment, but the cost impact of that much-maligned feature at this stage is likely minor). The nine HKP 14F are equipped with a “tactical radar” (i.e. a maritime surveillance radar), dipping sonar, as well as sonobuoy launcher and processing capability. Keen readers will note that there are no weapons or datalinks in the description above, and that omission is not by accident.

Somehow, with Sweden being no stranger to neither airborne ASW-operations nor datalinks, it was originally decided against acquiring weapons or datalinks for the NH90, despite the platform being a key integrated part in both the surface and sub-surface warfare plans of the Swedish Navy. The realisation that this is stupid is nothing new, and has been discussed since before the helicopters were delivered. Eventually, common sense prevailed, and the latest long-term plan dictate that the integration of the new lightweight torpedo (TP 47) and a datalink will begin before 2025.

Back in 2018 it was reported that the Swedish Armed Forces looked into mothballing all of the transport-roled HKP 14E operating in northern Sweden to save money. A year later the issues continued, with lack of spares and too few trained technicians leading to fewer (and more costly) flight hours than planned, meaning that the northern Swedish Army units in Arvidsjaur (the recently reinstituted ranger regiment) and Boden have had a hard time getting the flight hours they need.

A HKP 14F, readily identifiable thanks to the large radar disk under the front fuselage. Source: Henrik Rådman/Försvarsmakten

Shortly before Christmas this year, it was reported that the armed forces again are looking at cutting the NH90-fleet. Following preliminary studies, there are two main options: one is to continue with the NH90 and go through with the planned upgrades for the HKP 14F to get the datalink and torpedo, while also ordering another batch of Blackhawks. The second option is to retire all NH90s, and instead go for a joint UH-60 Blackhawk/MH-60 Seahawk-fleet for all the helicopter needs of the Swedish Armed Forces (there is a third helicopter, the light AW109 which is in service as the HKP 15 and seem set for retirement without direct replacement). It is somewhat unclear what is supposed to happen with the HKP 14E, but considering the wish to buy more Blackhawks in both scenarios and the apparent focus on the maritime HKP 14F it does sound like the days of the HKP 14E in the army cooperation role is numbered.

On paper the joint Blackhawk/Seahawk-fleet sounds all nice and simple, and I will say that I am a big proponent of cutting losses and not succumbing to the sunken cost fallacy. At the same time, it is evident that the truth isn’t quite as straightforward.

Another unit which uses the UH-60M is the Swedish SERE- and Personnel Recovery-training unit FÖS, which sort under K 3. Here a UH-60M is out carrying a number of personnel of FÖS earlier this summer. Source: Bezav Mahmod/Försvarsmakten

A key reason why the UH-60M Blackhawk deal was so successful is that it was a rather straightforward need (move healthy and sick people and equipment quickly from point A to B) and that it was accepted to just grab what was already in US service and paint some Swedish crowns on the side (slight exaggeration, but not by much). It is significantly more doubtful if the same is the case for the highly technical ASW-role, case in point being the Danish order for the MH-60R Seahawk (affectionally known as Romeo thanks to the version-letter). Denmark received approval back in 2010 for nine MH-60R, and they achieved IOC in 2017. However, crucially Denmark opted for a non-ASW fitted MH-60R, and decided to include some unique equipment (including the NATO-standard harpoon-hydraulic deck-locking system instead of the US RAST, as well as specific emergency equipment). As such, they have largely operated in the SAR and fisheries protection role, and only now are they being refitted (“during the coming years”) to be able to operate in the ASW-role. This puts it more or less at the same schedule as the Swedish NH90, depending on when exactly “the coming years” is and how long the Swedish integration starting before 2025 takes.

A Danish MH-60R Seahawk in Greenland. Note the additional rescue kit fitted to one of the pylons, and the radar under the forward belly. Source: Forsvaret

Another major question is how the blue-water Romeo works in the brackish littorals of the Baltic Sea? That’s less of an issue for Denmark, where the majority of the time the helicopters will be working out in the North Sea or around Greenland, but for Sweden the Baltic Sea is the main playing field of the Navy. This is acknowledged by the Swedish Armed Forces, and is one of the key reasons why the NH90 NFH wasn’t bought. The plan now is to be able to get a USN helicopter over some time during next summer, and get to see how that performs in Swedish conditions. Obviously, even if the Romeo is chosen, there is a sliding scale between a HKP 16-style off-the-shelf buy and a stripped Romeo fitted with Swedish ASW-equipment and weapons dedicated to the Baltic Sea-environment. Obviously, the most extreme version would be to grab a UH-60M and start installing the extra equipment in that in the same way as is being done with the HKP 14F, something that certainly would be more costly at the outset but would provide a higher degree of synergies and also be based on a simpler platform compared to the navalised MH-60 (there certainly are synergies between the UH-60M and the MH-60R, but there certainly are differences as well). Because for the time being, and unlike Denmark, no Swedish vessel is able to accept either the Blackhawk or the NH90 (the Visby can take aboard the AW109, which honestly might be the feature most sorely missed if it is retired without replacement), meaning that features such as folding blades and tail are just adding extra weight, meaning that a converted Blackhawk might be attractive. A middle of the road alternative that most likely would only combine the worst of the two alternatives would be to use the MH-60S Knighthawk, the multi-role sister to the Romeo, and fit it with an ASW-suite. The Sierra is in essence a navalised version of the UH-60L fitted with the same cockpit and navalised systems as the Romeo (minus the ASW-stuff), and is used for a number of different missions in the US Navy.

Notable is that production for the US Navy has ended for both versions in 2018 (Romeo) and 2015 (Sierra) respectively, though export orders are keeping the production line of the Romeo warm (latest of which is an Australian order for additional Blackhawks and Seahawks to replace their NH90s a decade early in both the transport- and maritime-roles). The Sierra just might be easier to work with if Sweden would want a Seahawk, but with a fully Swedish mission system and if they then would run into some hardware/space-related issues, but the Romeo is by far the most likely alternative (ironically, one of the few prospective MH-60S export orders was for a Qatari contract where a mixed MH-60R/S-fleet lost to the NH90).

However, if we look at the other extreme, and Sweden would simply order nine MH-60R according to USN specifications, there certainly is some interesting options here. To begin with aligning what will be a very small fleet with the standard of a larger operator does provide significant benefits when it comes to operating and upgrade costs, and both spares and weapons would likely be available at a rather cheap rate. The USN training pipeline could potentially also be used, something that might become more of an issue if the AW109 is withdrawn from service.

(Keen readers might notice that several of these points figured prominently during discussions about the HX-program.)

The Romeo and its sensors almost certainly isn’t as well suited to the Baltic Sea as a fully kitted out HKP 14F would be, but here comes the classic question: is a 75 or 90% solution at half the cost the best bang for the buck (note the numbers are pure examples)? A key detail is that finding submarines is extremely difficult, and despite the technological advances is still highly reliant on skilled personnel with a good understanding of local conditions. If switching to a solution that technically might not be the best fit allow the crews to train more, the end result might still be more scrap metal at the bottom of the sea than would otherwise be the case.

The operator stations of the Swedish HKP 14F. While all Swedish Armed Forces helicopters belong to the Air Force, many of those associated with the maritime helicopters have a background in the Navy (including both crew members aboard the helicopters as well as the current commanding officer of the unit). Source: Henrik Rådmark/Försvarsmakten

However – and this is an aspect that the Swedish evaluation will find hard to overlook – ASW is seen as a significant strategic interest for the Swedish defence industry, and killing the HKP 14F with its Saab-designed and built tactical mission system (including domestic sonar) will prove politically difficult. The orders are already far and few between, and with the Armed Forces in general short on funding a decision to acquire a standard Romeo is bound to raise uncomfortable questions. If the Mark 54 is good enough for the heliborne ASW-component, perhaps it is so for the rest of the force as well? What about sensors and processing units? This obviously also ties in with the same questions asked about the small submarine force, as many of the systems rest on a solid knowledge of similar topics (including e.g. Torped 47 as the obvious common weapon system). Giving up the locally developed sensors and weapons on the helicopter might very well come back to bite the Navy at a later stage when it is time for an upgrade of shipboard sensors and systems. As such, the decision on how to proceed with the helicopter part of things shouldn’t be taken lightly.

In the end, a Swedish Romeo-mod might still turn out to the be the best and cheapest option overall. However, the speedy UH-60M buy might not be the best reference point. Rather a highly complex project that hopefully can salvage the lessons (and potentially some hardware) from the current HKP 14F-fleet is to be expected, and I would not be surprised if the FOC date more or less corresponds to what would be the case for a full datalink and torpedo integration for the NH90.

An MH-60R Seahawk (in this case from HSM-73 “Battlecats”) – soon in a littoral theatre near you? Source: U.S. Navy photo by Mass Communication Specialist 2nd Class Logan C. Kellums via Wikimedia Commons

(And since I know you will ask: I don’t foresee Finland acquiring ex-Swedish NH90s to increase the size of the Finnish fleet, though I certainly could imagine some being acquired for cannibalisation in case the spares situation is as poor as the Australian decision seem to indicate)

The NH90 was supposed to become the gold-standard of military transport helicopters, utilising composite structures and high-tech avionics to provide a modern workhorse for the airlift needs in a host of European countries.

Almost immediately the grand vision hit rough waters, with significant teething troubles and delays. A chapter in itself was the joint Nordic helicopter program, which eventually ended up with the different countries all going more or less their own ways. In the end, Denmark and ordered the larger AW101 (ex-EH101), Norway got both the AW101 and the NH90 NFH (naval version), while Finland ordered the NH90 TTH and Sweden opted for two modified versions of the NH90, designated HKP 14E and 14F locally.

Choppers — Swedish HKP 14E visiting Kuopio, Finland, in 2016. Source: Own picture

In addition to the “baseline” teething troubles experienced by the project as a whole, the Swedes in a highly-publicised move decided that they wanted a higher cabin. This lead to a significant redesign, which brought added costs and delays. In the background also loomed persistent rumors that the evaluation made by the Swedish Defence Forces had been won by another contender (the Sikorsky S-92), and that the NH90 had been bought due to political considerations.

While the Finnish helicopter program also suffered delays, at one point forcing the once-retired Mi-8’s back into service, the Finnish Army rather quickly regained their footing. In part thanks to the delays, Patria was negotiated to take a bigger role in the overhaul of not only the Finnish but also of foreign helicopters, and by not requiring all documentation and systems to be fully operational immediately, the Army was able to phase the NH90-fleet into use at a relatively fast pace (still years late compared to the original plan). One of the breakthrough moments was the major exercise Pyörremyrsky 2011, which saw a formation of 9 helicopters perform an airlift operations. A first, also by international standards.

In the meantime Sweden was still suffering from issues with regards to the localisation, and the attitude towards incomplete or temporary paperwork was not as forgiving. To make matters more urgent, like in Finland, Sweden was also in the process of retiring their earlier helicopters. In this case, the retirement of the Hkp 10B (Super Puma) meant that the forces in Afghanistan would be without a MEDEVAC helicopter for the foreseeable future, something which was deemed unacceptable. To solve the issue an urgent order for 15 UH-60M Blackhawk was placed in 2011 as a stop-gap solution. Influenced by the troublesome HKP 14 program, the helicopters were ordered according to US standards, with one of the chief programme executives being rumoured to have summed up the order with “I don’t care if it reads ‘US ARMY’ on their sides, just get them here!”.

Swedish HKP 16 (UH-60M Blackhawk) in joint operations with the ground elements of NBG 15. In an ironic twist, the Finnish detachment to the battle group was a NH90 MEDEVAC unit. Source: Alexander Karlsson/Försvarsmakten

The new Blackhawks provided stellar service in Afghanistan, and once the operation winded down they were integrated into the Swedish Air Force’s Helicopter Wing as part of the medium lift capability of the defence forces. By all accounts the helicopters, locally designated HKP 16, have performed well, and the deal is a prime example of something acquired outside of original plans quickly finding its place in the greater scheme of things. At the same time the transport version HKP 14E was slowly getting introduced into service, but still the critique didn’t let up. The marine version HKP 14F (not to be confused with the international naval version NH90 NFH) was being delayed further until 2015, and entered service both without any kind of anti-submarine torpedo as well as without a working data link to relay information to and from other units.

NH 90 on show — Finnish NH90 during an aerial display in Vaasa in early 2018. Source: Own picture

The latest blow came when it was clear that the Air Force had looked into mothballing all nine HKP 14E, due to the extremely high operating costs, over 19,000 EUR per flight hour. At the heart of the issue lies accounting. The majority of the costs does not come from fuel, but from fixed costs such as yearly overhauls. The high cost means that the Air Force prefer to use the Blackhawks whenever possible, as they sport a flight hour cost one-fifth of that of the HKP 14 . This in turns leads to even lower usage for the HKP 14, further pushing up the cost per hour. To make matters worse, there is speculation that part of the fixed costs are depreciation, i.e. accounting for the fact that the value of the helicopter diminishes per year. A handy tool when it comes to calculating investments in regular companies, a not-so-handy one when it comes to defence budgets.

This is in stark contrast to the Finnish numbers, where the flight hour cost is on a steady downwards trajectory. For 2017 the budgeted flight hour cost was 15,900 EUR, while for 2018 it is down in the neighborhood of around 10,000 EUR. This was confirmed by colonel Jaro Kesänen, Commanding Officer of Utti Jaeger Regiment which is home to the Helicopter Battalion. Speaking as a private citizen, Kesänen noted in a non-formal Twitter exchange that the NH90 is an appreciated asset in the Finnish Defence Forces and that the flight hour cost is within the range envisioned when the helicopters were acquired. Notable is that in the case of Finland the NH90 is the sole transport helicopter available to the Defence Forces (though a limited number of Border Guard helicopters can also be called upon by the authorities), and the caveat should be made that rarely does the Finnish Defence Forces openly voice negative opinions about their own systems.

In the last weeks two major reports on the future of the Swedish Defence Forces have been released. The first was SOU 2018:7 which looked at the long-term needs for new equipment to the Swedish Defence Forces (also known as “Wahlbergs review”). The review looked into mothballing either all HKP 14 or only the army cooperation HKP 14E to make budgetary saving. The conclusions presented was that few to none savings would be made if the HKP 14E was retired, and in case all HKP 14 were retired this would have too large negative effects in the maritime domain. The second report was the Defence Forces’ outlook at how to expand up until 2035 (known as PerP). The report only deals with the Helicopter Wing in passing, and does not mention individual systems. What it does note is identify the need to grow the organisation and its capabilities, in part due to the need for airmobile units. As such, the career of the HKP 14 seems set to continue in the Swedish Defence Forces. Time will tell if it will grow into a beautiful swan, or whether it is destined to stay the ugly duckling of the Helicopter Wing.

Corporal Frisk

Tag: UH-60 Blackhawk

Enter Seahawk – Exit Whitefox?

Of Helicopters and High Costs